User manual HYOSUNG GT 650 R

[. . . ] Printed in KOREA For U. S. A This manual should be considered a permanent part of the motorcycle and should remain with the motorcycle when resold or otherwise transferred to a new owner or operator. The manual contains important safety information and instructions which should be read carefully before operating the motorcycle. 1 (Standard type) 2 (Sports type) 3 FOREWORD THANK YOU for choosing Hyosung motorcycle. We at Hyosung have designed, tested and produced these motorcycles using the most modern technology available to provide you with much happy, enjoyable, safe riding. Motorcycling is one of the most exhilarating sports and insure you to enjoy riding and you should become thoroughly familiar with the information presented in this Owner's Manual before riding the motorcycle. [. . . ] The oil level is located between the "Lower line(L)" the Upper line(F)" and " . When below the" Lower line(L)" refill the , oil between the" Lower line(L)"and the " Upper line(F)" . The coolant should be kept between the "F" "L" (FULL) and (LOW) level lines in the reservoir tank at all times. Inspect the level every time before riding while the motorcycle vertically. If the coolant is found lower "L"level line, add properly mixed than the coolant in the following way : If the reservoir tank is emptied, pour the engine coolant to the reservoir tank and radiator. Remove the filler cap and add properly mixed coolant through the filler hole "F" line. until it reaches the Refer to the FUEL, ENGINE OIL AND COOLANT RECOMMENDATION section (14 page). 48 WARNING Engine coolant is harmful or fatal if swallowed or inhaled. If coolant gets in eyes, flush eyes with water and seek medical attention. Keep out of the reach of children and aminals. SIDE COWLING INNER (FOR & ) & have the "side cowling inner " at the rightside. To disassemble the "side cowling inner", remove the two bolts . WARNING Do not open the radiator cap when the engine is hot, as you may be injured by escaping hot liquid or vapor. NOTE Adding only water will dilute the engine coolant and reduce its effectiveness. Add 50:50 mixture of engine coolant and water. CHANGING THE COOLANT Change the coolant every two years. NOTE About 1. 6 of coolant will required when filling the radiator and reservoir tank. 49 RIDING TIPS STARTING THE ENGINE Before attempting to start the engine make sure: 1. Inspect every day once before riding the motorcycle. When the engine is cold : 1. Immediately after the engine starts, return the choke lever halfway and warm up the engine. Return the choke lever all the way back to its disengaged position. When the engine is warm : 1. Push the starter switch. CAUTION Operation of the carburetor choke system is not necessary when the engine is warm. WARNING The is equipped with the side stand ignition interlock system. If the transmission is in neutral or side stand up, you can only start the engine with pulling in the clutch lever. This side stand ignition interlock system prevents the motorcycle from being started with side stand down. Make sure that the side stand igintion interlock system is working properly before riding. WARNING Running the engine indoors or in a garage can be hazardous. Exhaust gas contains carbon monoxide, a gas that is colorless and odorless and can cause death or severe injury. Only run the engine outdoors where there is a fresh air. CAUTION Running the engine too long without riding may cause the engine to overheat. Overheating can result in damage to internal engine components and discoloration of exhaust pipes. Shut the engine off if you cannot begin your ride promptly. CAUTION These motorcycles always come on the head lamp, meter lamp and tail lamp when starting the engine. 50 CAUTION Do not engage the starting motor for more than five seconds at a time as it may overheat the wiring harness and starting motor. [. . . ] Check the ignition system for intermittent spark. Check the engine idle speed. CAUTION When occur any trouble, the best way is to consult your Hyosung dealer for repairs. CAUTION High pressure washers can damage your motorcycle. (especially the radiator pin) High pressure washers such as those found at coin-operated car washes have enough pressure to damage the parts of your motorcycle. Do not use high pressure washers to clean your motorcycle. WHEN KEEPING FOR LONG PERIOD 1. Remove the battery from the motorcycle. WASHING YOUR motorcycle With some care, your motorcycle can be washed in a similar manner to washing an automobile. NOTE Avoid spraying or allowing water to flow over the following places : Spark plug Fuel tank cap Carburetor 79 Use a garden hose at low pressure to remove the majority of dirt or other debris. [. . . ]