User manual HYOSUNG GV650
DON'T FORGET : ALWAYS READ THE USER GUIDE BEFORE BUYING !!!
If this document matches the user guide, instructions manual or user manual, feature sets, schematics you are looking for, download it now. Diplodocs provides you a fast and easy access to the user manual HYOSUNG GV650. We hope that this HYOSUNG GV650 user guide will be useful to you.
Manual abstract: user guide HYOSUNG GV650
Detailed instructions for use are in the User's Guide.
[. . . ] This manual should be considered a permanent part of the motorcycle and should remain with the motorcycle when resold or otherwise transferred to a new owner or operator. The manual contains important safety information and instructions which should be read carefully before operating the motorcycle.
1
FOREWORD
THANK YOU for choosing Hyosung motorcycle. We at Hyosung have designed, tested and produced this motorcycle using the most modern technology available to provide you with much happy, enjoyable, safe riding. Motorcycling is one of the most exhilarating sports and insure your riding enjoyment, you should become thoroughly familiar with the information presented in this Owner's Manual before riding the motorcycle. [. . . ] Children and pets may be harmed by swallowing new or used engine oil or solvent. Continuous contact with used engine oil has been found to cause skin cancer in laboratory animals. Before replacing the engine oil filter cap , be sure to check that the engine oil filter spring and the" O" are installed ring correctly. Use new" O" each time the ring engine oil filter element is replaced. Replace the oil filter cap and tighten the nuts securely but do not over tighten them.
OIL FILTER INSTALLATION
INSERTION DIRECTION
LUSTER MATERIAL
HYOSUNG 16510HN910
OUTSIDE
CAUTION
When install the oil filter, necessarily, " HYOSUNG" character and "16510HN910" part' NO. install toward s the outside, otherwise can damage the engine.
37
9. Approximately 3, 200 of oil will be required.
COOLANT
COOLANT LEVEL
CAUTION
Approximately 3, 000 of oil must be required when changing oil only without replacing the oil filter.
CAUTION
In case of the engine oil pouring excessively, the engine output being made insufficient. Confirm the oil level with the oil level lens after waiting about a minute next to stopping the engine. The oil level is located between the "Lower line(L)" the and "Upper line(F)" . When below the"Lower line(L)" refill the , oil between the"Lower line(L)"and the "Upper line(F)" . The coolant should be kept between the "F" "L" (FULL) and (LOW) level lines in the reservoir tank at all times. Inspect the level every time before riding while the motorcycle vertically. If the coolant is found lower "L"level line, add properly mixed than the coolant in the following way : If the reservoir tank is emptied, pour the engine coolant to the reservoir tank and radiator.
Remove the filler cap and add properly mixed coolant through the filler hole until it "F" line. reaches the Refer to the FUEL, ENGINE OIL AND COOLANT RECOMMENDATION section (12 page).
38
WARNING
Engine coolant is harmful or fatal if swallowed or inhaled. If coolant gets in eyes, flush eyes with water and seek medical attention. Keep out of the reach of children and aminals.
OPEN THE RADIATOR CAP
Remove the right front side cover to operate the radiator cap . To disassemble the right front side cover , remove the two mounting bolt .
WARNING
You can be injured by scalding fluid or steam if you open the radiator cap when the engine is hot. After the engine cools, wrap a thick cloth around cap and carefully remove the cap by turning it a quarter to allow pressure to escape and then turn the cap all the way off.
NOTE
Adding only water will dilute the engine coolant and reduce its effectiveness. Add 50 : 50 mixture of engine coolant and water.
CHANGING THE COOLANT
Change the coolant every two years.
NOTE
About 1. 6 of coolant will be required when filling the radiator and reservoir tank.
39
RIDING TIPS
STARTING THE ENGINE
Necessary attempt before start the engine : 1. Immediately after the engine starts, return the choke lever halfway and warm up the engine. Return the choke lever all the way back to its disengaged position.
When the engine is warm :
1. Push the starter switch.
CAUTION
Operation of the carburetor choke system is not necessary when the engine is warm.
WARNING
The is equipped with the side stand ignition interlock system. [. . . ] In case a fuse blows there is a 30A for main and 15A for head lamp spare fuse. 15A head lamp fuse protects the head lamp and high beam indicator lamp.
CAUTION
Never use other than specified 30A or 15A fuse. Installing a fuse of incorrect rating may seriously damage the electrical system. You should consult your Hyosung dealer or a qualified service mechanic immediately.
66
WHEN THE ENGINE REFUSES TO START TROUBLE SHOOTING
If the engine refuses to start, perform the following inspections to determine the cause. [. . . ]
DISCLAIMER TO DOWNLOAD THE USER GUIDE HYOSUNG GV650
Click on "Download the user Manual" at the end of this Contract if you accept its terms, the downloading of the manual HYOSUNG GV650 will begin.