User manual HYOSUNG SD 50

[. . . ] IMPORTANT BREAK-IN INFORMATION FOR YOUR MOTORCYCLE WARNING/CAUTION/NOTE The first 1000km(600miles) are the most important in the life of your motorcycle . Proper break-in operation during this time will help ensure maximum life and performance from your new motorcycle. Hyosung parts are manufactured of high quality materials, and manufactured parts are finished to close tolerances. Proper break-in operation allows the machined surfaces to polish each other and mate smoothly. [. . . ] OIL INDICATOR LIGHT When the engine oil level in the tank becomes too low requiring"HYPOL OIL"refilling. When the oil level check light turns on, the remaining amount of oil has become approximately 300. OF PUSH CK PUSH 7 G I NITI ON F ON G I NITIO N PUSH SPEEDOMETER The speedometer indicates the road speed in kilometers per hour. F OF OF F ON KEY LO LO For preventing steal, Lock the steering. Pull out the key while from Lock to OFF. ! CAUTION HORN SWITCH Check if the steering is locked. When it is not locked, Turn the handle right a little. Press the switch to operate the horn. DIMMER SWITCH TURN SIGNAL SWITCH DIMMER SWITCH TURN SIGNAL SWITCH " " It is for left/right turning or changing lanes. " "position - for right turn signal " "position - for left turn signal ""Push the switch to cancel the operation. "position - for headlight low beam. ! CAUTION "when other vehicle is Set the dimmer switch" running in front or against. LIGHT SWITCH ! CAUTION Turn off the lamp right after completing the turn or lane change. If you keep the lamp on, it could cause other drivers to be confused. HORN SWITCH LIGHT SWITCH 8 " "position All light go off. " "position The headlight, meter lamp and taillight come on. STARTER BUTTON Push in the electric starter button to rotate the stater motor. 4. HOW TO USE HOW TO OPEN THE SEAT You can use the helmet holder/Trunk after opening the seat. To unlock the seat, insert the ignition key into the lock and turn it counterclockwise. To lock the seat, push down firmly until the seat latch snaps into the locked position. NOTE: If the front or rear brake lever is not squeezed, the starter motor will not rotate. ! CAUTION SEAT LOCK When the starter motor doesn' rotate within t 5 seconds after pushing the button, try again after 10 seconds for preventing the damage on battery. HELMET HOLDER To search the helmet holder, open the seat. STARTER BUTTON Lock the seat, after hang helmets tail on a helmet holder. 9 THE PERSONAL TRUNK Keep the maintenance manual in the personal trunk. GASOLINE AND ENGINE OIL HOW TO PROVIDE THE GASOLINE FUEL TANK CAP ! CAUTION The trunk could be heated. When the engine is cold, idle it for a while. ! CAUTION ! CAUTION Don' idle it indoor where there is little or no t ventilation available. The exhaust gas including carbon monoxide is extremely poisonous. Depress the start button right after started. When the start motor doesn' rotate witht in 5 seconds after pushing the start button, try again after 10 seconds for preventing the damage on battery. Start using the kick starter lever You can start using the kick starter lever when there is some problem in battery. Set the ignition switch"ON" Press forcefully the kick starter lever. Wnen it doesn' start after several trial, t turn the throttle grip to ~¼ position. FULL THROTTLE OPERATION ! CAUTION 12 ! CAUTION When started, return the throttle grip. When started, return the kick starter lever. HOW TO START OFF ! CAUTION Don' let the engine run excessively before t riding. Return the center For returning the motorcycle forward lever with left hand right hand. center stand, push the gripping the rear brake and the rear carrier with Check the safety Turn on the left turn signal lamp and check the safety. [. . . ] FUSE REAR BRAKE RANGE PIN ADJUSTER NUT ! CAUTION When it is beyond the required range, replace the brake shoe. Fix part of nut to pin or the serious accident can be caused by the brake failure. ! CAUTION Always be sure to replace the blown fuse with the correct amperage fuse. If the replaced fuse is blown in a short time, it means there are other problems. Don' pour water on the fuse box when t washing. 23 BATTERY TERMINAL Clean the battery terminal when it is dusty or rusted. [. . . ]