User manual KUSSMAUL 091-9HP

[. . . ] FILE: 091-9HP. PM6. 5 DATE: 11-17-04 INSTRUCTION MANUAL AUTO-PUMP HP 120 VAC HIGH PRESSURE AIR COMPRESSOR SYSTEM MODEL #091-9HP ® INPUT: 120 volt, 60 Hz, 4. 0 AMPS 1 YEAR WARRANTY KUSSMAUL ELECTRONICS CO. , INC. 170 CHERRY AVE. , WEST SAYVILLE, N. Y. 11796 TEL: in NY 631-567-0314 TOLL FREE: 800-346-0857 FAX: 631-567-5826 INTRODUCTION The 091-9HP Auto-Pump Air Compressor system is a 120 volt 60 Hz split capacitor A. C. [. . . ] AT LOWER VOLTAGES THE PUMP WILL NOT START CAUTION NO CONDENSATE OR WATER MUST BE ALLOWED TO ENTER OR ACCUMULATE IN THE OUTPUT OF THE AUTO PUMP. ROUTE OUTPUT PRESSURE LINE DOWNWARD FROM AUTO PUMP TO PERMIT MOISTURE TO DRAIN AWAY. CONDENSATE TRAP MUST BE DRAINED WEEKLY WATER IN THE PUMP OUTLET WILL INDUCE FAILURE ! WATER DAMAGE WILL VOID WARRANTY VEHICLE TUBING INSTALLATION 1. Mount all components in a suitable location, preferably in a high area above the air system . Do not mount in engine compartment or near any source of heat or dirt . The system may be connected to any point in the vehicle's air system . CAUTION no condensate or water must be allowed to enter or accumulate in the output of the Auto Pump . Route output pressure line downward from Auto Pump to permit moisture to drain away . Water in the pump outlet will induce failure . DRAIN CONDENSATE SEPARATOR WEEKLY 4. Use Teflon tape, or equivalent on all connections to insure no leakage of air. The recommended installation of the Auto Pump air compressor system is shown below. Note that an external check valve is located between the compressor and the pressure switch. Connect a suitable piece of flexible tubing from the outlet port of compressor to the air tank . [. . . ] shall have no liability for damages of any kind to associated equipment arising from the installation and /or use of the Kussmaul Electronics Company, Inc. The purchaser, by the acceptance of the equipment, assumes all liability for any damages which may result from its installation, use or misuse, by the purchaser, his or its employees or others. CAUTION: WATER IN THE PUMP OUTLET WILL INDUCE FAILURE WATER DAMAGE WILL VOID WARRANTY [. . . ]