User manual THETFORD ELECTRA MAGIC

[. . . ] Simply call Thetford's Customer Relations Department at 1-800-543-1219 1-800-521-3032 Electrical Hookup RV and Marine Models Connect your 1-Volt or 4-Volt model Electra Magic directly to the appropriate D. C. (Black wire to positive [hot], white to negative [ground]. ) Important ­ Be sure polarity of power supply has been properly determined and correctly connected to lead wires before operating. Installation RV Model 1. While holding bolt up so the head touches underside of closet flange, install one nut on each bolt and screw nuts down until they touch top of gauge. [. . . ] With a sharp blow drive each slide back until it slides under nut and snaps into position. 8. If slides cannot be driven by one or two blows, remove toilet and adjust each nut one-half turn upward and repeat procedure from Step 6. If toilet wobbles excessively, remove slides by catching tabs with a hooked instrument and pulling forward, as shown below. Lift toilet off, adjust each nut one-half turn downward and repeat procedure from Step 6. Extension Handle Valve Toilet Model 24320 Only Multiple positions using extension handle valve: 08707 08737 02792 08636 slide-eZ Valve screw lockwasher Mounting Bracket 03915 screw 08737 02792 08707 08636 12979 05248 screw lockwasher slide-eZ Valve Mounting Bracket Base Moulding Base Moulding 03915 screw 5 Parts List RV and Marine Models 1 2 3 4 5 6 17 18 (12- and 24-Volt Models are available. ) 19 20 21 22 23 24 25 26 27 28 7 8 9 10 11 12 29 13 14 15 16 Product ID Label Key part no. no. Description 1 03921 Hinge pin (2) 2 03922 Retaining Ring (2) 3 03916 seat Cover Assy. * 4 08166 lid seal 5 03953 left Hinge* 6 03904 seat & Bumper Assy. * 7 03936 Cap* 8 05656 splash Guard 9 03912 Cover & Bowl Assy. * 10 03984 Vinyl skirt Assy. 11 03946 inlet tube 12 12938 left side Base Moulding* 13 12979 Base Moulding w/ Hole* 14 08167 Main Housing seal 15 1284057 Main Housing Assy. * 16 03943 Front screw (2) 17 03923 Cover Mtg. 19 03905 20 03927 21 03990 22 03979 23 24615 24 03937 25 03928 26 03925 27 05700 14082 28 05534 29 03950 14083 30 05248 30 31 Description Right Hinge* nut (4) lock Washer (4) Rear screw (2) level indicator Hinge Mtg. screw (4) Motor Kit: 12 Volt Motor Kit: 24 Volt Filter Cone pump Assy. : 12 Volt** pump Assy. : 24 Volt** Right side Base Moulding* 31 03915 Moulding Mtg. screw (2) ** includes Motor * indicate Color When ordering 6 RV Slide-EZ Valve Key part no. 1 12836 2 03911 3 03913 4 08637 5 08737 6 24304 7 02690 8 12525 9 08636 10 12838 Description slide-eZ Valve Handle* Retaining Ring slides (2) screw (4) Flange seal nut (2) Closet Bolt (2) Mtg. Bracket (2) Mounting package (comprised of Key parts 4-9) note: slide-eZ Valve no. 1 03940 2 08637 3 01663 4 12984 5 12983 6 08636 7 05063 Description sump Assy. Bracket (2) Mounting package (comprised of Key parts 2-6) Record Your Product ID Information Here MODel CODe : : PaRT NO : (See Parts list on Pg. 6 for location of Product ID label) (For Service/Part info, call 1-800-543-1219) 1-800-521-3032) 7 Disassembly RV and Marine Models 1. Remove two () #09 cover mounting screws and #094 Motor Cover Assembly. Remove two () #09 cover mounting screws and #094 Motor Cover Assembly. Note: If you have a #24320 extension handle unit, cotter pin and extension handle must be removed at this point. Remove two () #0915 moulding mounting screws and remove two () base mouldings (See Pg. [. . . ] DO NOT use highly concentrated or high-acid content household cleaner, nor those containing abrasive, such as cleaning or scouring powder. These may damage the seals or the plastic parts of the toilet. Storage A. Completely evacuate unit again. Winter Use/Winterizing For winter use, replace one-half of the charge water with an approved RV anti-freeze. [. . . ]